Skip to Content

Rule

Airworthiness Directives; REIMS AVIATION S.A. Airplanes

Document Details

Information about this document as published in the Federal Register.

Enhanced Content

Relevant information about this document from Regulations.gov provides additional context. This information is not part of the official Federal Register document.

Published Document

This document has been published in the Federal Register. Use the PDF linked in the document sidebar for the official electronic format.

Start Preamble

AGENCY:

Federal Aviation Administration (FAA), DOT.

ACTION:

Final rule; request for comments.

SUMMARY:

We are adopting a new airworthiness directive (AD) for REIMS AVIATION S.A. Model F406 airplanes. This AD results from mandatory continuing airworthiness information (MCAI) issued by the aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as detachment of the pilot's rudder control pedal in flight. We are issuing this AD to require actions to address the unsafe condition on these products.

DATES:

This AD is effective August 18, 2015.

The Director of the Federal Register approved the incorporation by reference of a certain publication listed in the AD as of August 18, 2015.

We must receive comments on this AD by October 1, 2015.

ADDRESSES:

You may send comments by any of the following methods:

  • Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
  • Fax: (202) 493-2251.
  • Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590.
  • Hand Delivery: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

For service information identified in this AD, contact ASI Aviation, Aérodrome de Reims Prunay, 51360 Prunay, FRANCE; phone: +33 3 26 48 46 65; fax: +33 3 26 49 18 57; email: none; Internet: http://asi-aviation.fr/​asi-aviation-support/​1.html (requires user name and password). You may view this referenced service information at the FAA, Small Airplane Directorate, 901 Start Printed Page 49128Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148. It is also available on the Internet at http://www.regulations.gov by searching for locating Docket No. FAA-2015-3398.

Examining the AD Docket

You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-3398; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

Start Further Info

FOR FURTHER INFORMATION CONTACT:

Albert J. Mercado, Aerospace Engineer, FAA, Small Airplane Directorate, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329-4119; fax: (816) 329-4090; email: albert.mercado@faa.gov.

End Further Info End Preamble Start Supplemental Information

SUPPLEMENTARY INFORMATION:

Discussion

The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued AD No.: 2015-0159-E, dated July 31, 2015 (referred to after this as “the MCAI”), to correct an unsafe condition for the specified products. The MCAI states:

An occurrence was reported where one pilot rudder control pedal of an F 406 aeroplane detached in flight. No change in aeroplane attitude occurred. The rudder was controlled using the co-pilot rudder pedals, and the flight continued uneventfully until a safe landing was performed.

This condition, if not detected and corrected, could result in loss of directional control of the aeroplane.

To address this unsafe condition, ASI Aviation issued Service Bulletin (SB) F406-104 to provide inspection instructions.

For the reason described above, this AD requires inspection of the rudder control pedal torque tubes, both left-hand (LH) and right-hand (RH), and, depending on findings, replacement with a serviceable part.

This AD also requires inspection before new installation of rudder control pedal torque tubes.

You may examine the MCAI on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-3398.

Related Service Information Under 1 CFR Part 51

ASI AVIATION has issued Service Bulletin No.: F406-104, dated July 28, 2015. The actions described in this service information are intended to correct the unsafe condition identified in the MCAI. The service information describes procedures for inspection of the left-hand and right-hand rudder control pedal torque tubes, and, depending on findings, replacement with a serviceable part. This service information is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section of this AD.

FAA's Determination and Requirements of the AD

This product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to our bilateral agreement with this State of Design Authority, they have notified us of the unsafe condition described in the MCAI and service information referenced above. We are issuing this AD because we evaluated all information provided by the State of Design Authority and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design.

FAA's Determination of the Effective Date

An unsafe condition exists that requires the immediate adoption of this AD. The FAA has found that the risk to the flying public justifies waiving notice and comment prior to adoption of this rule because detachment of the pilot rudder control pedal in flight could result in loss of airplane directional control. Therefore, we determined that notice and opportunity for public comment before issuing this AD are impracticable and that good cause exists for making this amendment effective in fewer than 30 days.

Comments Invited

This AD is a final rule that involves requirements affecting flight safety, and we did not precede it by notice and opportunity for public comment. We invite you to send any written relevant data, views, or arguments about this AD. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2015-3398; Directorate Identifier 2015-CE-031-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this AD. We will consider all comments received by the closing date and may amend this AD because of those comments.

We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this AD.

Costs of Compliance

We estimate that this AD will affect 7 products of U.S. registry. We also estimate that it will take about 5 work-hours per product to comply with the basic requirements of this AD. The average labor rate is $85 per work-hour.

Based on these figures, we estimate the cost of the AD on U.S. operators to be $2,975, or $425 per product.

In addition, we estimate that any necessary follow-on actions would take about 20 work-hours and require parts costing $10,000, for a cost of $11,700 per product. We have no way of determining the number of products that may need these actions.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that this AD:

(1) Is not a “significant regulatory action” under Executive Order 12866,Start Printed Page 49129

(2) Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),

(3) Will not affect intrastate aviation in Alaska, and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

Start List of Subjects

List of Subjects in 14 CFR Part 39

  • Air transportation
  • Aircraft
  • Aviation safety
  • Incorporation by reference
  • Safety
End List of Subjects

Adoption of the Amendment

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

Start Part

PART 39—AIRWORTHINESS DIRECTIVES

End Part Start Amendment Part

1. The authority citation for part 39 continues to read as follows:

End Amendment Part Start Authority

Authority: 49 U.S.C. 106(g), 40113, 44701.

End Authority
[Amended]
Start Amendment Part

2. The FAA amends § 39.13 by adding the following new AD:

End Amendment Part

2015-16-07 REIMS AVIATION S.A.: Amendment 39-18232; Docket No. FAA-2015-3398; Directorate Identifier 2015-CE-031-AD.

(a) Effective Date

This airworthiness directive (AD) becomes effective August 18, 2015.

(b) Affected ADs

None.

(c) Applicability

This AD applies to Reims Aviation S.A. Model F406 airplanes, serial numbers 0001 through 0098, certificated in any category.

(d) Subject

Air Transport Association of America (ATA) Code 27: Flight Controls.

(e) Reason

This AD was prompted by mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as detachment of the pilot's rudder control pedal in flight. We are issuing this AD to detect and correct cracking of the pilot rudder control pedal which, if not corrected, could result in detachment of the pedal with possible loss of airplane directional control.

(f) Actions and Compliance

Unless already done, do the actions in paragraphs (f)(1) through (f)(4) of this AD.

(1) Before further flight after August 18, 2015 (the effective date of this AD), do a visual inspection and a dye or fluorescent penetrant inspection of the rudder control pedal torque tubes, LH (Part Number (P/N) 5115260-1) and RH (P/N 5115260-2), following the instructions of PART A of ASI AVIATION Service Bulletin No.: F406-104, dated July 28, 2015.

(2) If no crack is detected during the inspection required by paragraph (f)(1) of this AD, within 100 hours time-in-service (TIS) after August 18, 2015 (the effective date of this AD), do a magnetic particle inspection of the rudder control pedal torque tubes, LH (P/N 5115260-1) and RH (P/N 5115260-2), following the instructions of PART B of ASI AVIATION Service Bulletin No.: F406-104, dated July 28, 2015.

(3) If any crack is detected on a rudder control pedal torque tube during the inspection required by paragraph (f)(1) or (f)(2) of this AD, before further flight, replace the affected part with a serviceable part following the instructions of ASI AVIATION Service Bulletin No.: F406-104, dated July 28, 2015.

(4) For the purpose of this AD, a serviceable part is a rudder control pedal torque tube that has had a magnetic particle inspection following the instructions of PART B of ASI AVIATION Service Bulletin No.: F406-104, dated July 28, 2015, and no cracks were found.

(5) You may install a rudder control pedal torque tube P/N 5115260-1 (LH) or P/N 5115260-2 (RH) on an airplane, provided it is a serviceable part.

(g) Other FAA AD Provisions

The following provisions also apply to this AD:

(1) Alternative Methods of Compliance (AMOCs): The Manager, Standards Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Albert J. Mercado, Aerospace Engineer, FAA, Small Airplane Directorate, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329-4119; fax: (816) 329-4090; email: albert.mercado@faa.gov. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO.

(2) Airworthy Product: For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered FAA-approved if they are approved by the State of Design Authority (or their delegated agent). You are required to assure the product is airworthy before it is returned to service.

(3) Reporting Requirements: For any reporting requirement in this AD, a federal agency may not conduct or sponsor, and a person is not required to respond to, nor shall a person be subject to a penalty for failure to comply with a collection of information subject to the requirements of the Paperwork Reduction Act unless that collection of information displays a current valid OMB Control Number. The OMB Control Number for this information collection is 2120-0056. Public reporting for this collection of information is estimated to be approximately 5 minutes per response, including the time for reviewing instructions, completing and reviewing the collection of information. All responses to this collection of information are mandatory. Comments concerning the accuracy of this burden and suggestions for reducing the burden should be directed to the FAA at: 800 Independence Ave. SW., Washington, DC 20591, Attn: Information Collection Clearance Officer, AES-200.

(h) Related Information

Refer to MCAI European Aviation Safety Agency (EASA) AD No.: 2015-0159-E, dated July 31, 2015, for related information. You may examine the MCAI on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-3398.

(i) Material Incorporated by Reference

(1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.

(2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise.

(i) ASI AVIATION Service Bulletin No.: F406-104, dated July 28, 2015.

(ii) Reserved.

(3) For service information identified in this AD, contact ASI Aviation, Aérodrome de Reims Prunay, 51360 Prunay, FRANCE; phone: +33 3 26 48 46 65; fax: +33 3 26 49 18 57; email: none; Internet: http://asi-aviation.fr/​asi-aviation-support/​1.html (requires user name and password).

(4) You may view this service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148. It is also available on the Internet at http://www.regulations.gov by searching for locating Docket No. FAA-2015-3398.

(5) You may view this service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/​federal-register/​cfr/​ibr-locations.html.

Start Signature

Issued in Kansas City, Missouri on August 6, 2015.

Earl Lawrence,

Manager, Small Airplane Directorate, Aircraft Certification Service.

End Signature End Supplemental Information

[FR Doc. 2015-19901 Filed 8-14-15; 8:45 am]

BILLING CODE 4910-13-P