This PDF is the current document as it appeared on Public Inspection on 06/26/2017 at 08:45 am.
Federal Aviation Administration (FAA), DOT.
Notice of proposed rulemaking (NPRM).
We propose to adopt a new Airworthiness Directive (AD), for certain Bombardier, Inc., Model CL-600-2B16 (CL-604 Variant) airplanes. This proposed AD was prompted by reports of in-flight uncommanded rudder movements. This proposed AD would require modification of the wiring for the yaw damper control system. We are proposing this AD to address the unsafe condition on these products.
We must receive comments on this proposed AD by August 11, 2017.
You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods:
- Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
- Fax: 202-493-2251.
- Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590.
- Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this NPRM, contact Bombardier, Inc., 400 Côte Vertu Road West, Dorval, Québec H4S 1Y9, Canada; Widebody Customer Response Center North America toll-free telephone 1-866-538-1247 or direct-dial telephone 1-514-855-2999; fax 514-855-7401; email firstname.lastname@example.org; Internet http://www.bombardier.com. You may view this referenced service information at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425-227-1221.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017-0626; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone 800-647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.Start Further Info
FOR FURTHER INFORMATION CONTACT:
Cesar Gomez, Aerospace Engineer, Airframe and Mechanical Systems Branch, ANE-171, FAA, New York Aircraft Certification Office, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone 516-228-7318; fax 516-794-5531.End Further Info End Preamble Start Supplemental Information
We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2017-0626; Directorate Identifier 2016-NM-210-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments.
We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD.
Transport Canada Civil Aviation (TCCA), which is the aviation authority for Canada, has issued Canadian Airworthiness Directive CF-2016-38, effective December 12, 2016 (referred to after this as the Mandatory Continuing Airworthiness Information, or “the MCAI”), to correct an unsafe condition for certain Bombardier, Inc., Model CL-600-2B16 (CL-604 Variant) airplanes. The MCAI states:
The [Canadian] AD CF-2013-22 [which corresponds to FAA AD 2014-16-06, Amendment 39-17930 (79 FR 48972, August 19, 2014)] was issued on 12 August 2013 to mandate the introduction of an emergency procedure to the Aeroplane Flight Manual to address the uncommanded rudder movement.
Since the original issue of [Canadian] AD CF-2013-22, Bombardier Aerospace has developed a wiring modification for the yaw damper control system to prevent uncommanded movement of the rudder.
This [Canadian] AD mandates the incorporation of Service Bulletins (SB) 604-22-007 and 605-22-002 * * * *.
This proposed AD would require modification of the wiring for the yaw damper control system. You may examine the MCAI in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017-0626.
Related Service Information Under 1 CFR Part 51
Bombardier, Inc., issued Service Bulletin 604-22-007, Revision 01, dated July 25, 2016; and Service Bulletin 605-22-002, Revision 01, dated July 25, 2016. The service information describes procedures for modifying the wiring harness for the yaw damper control system. These documents are distinct since they apply to different airplane configurations. This service information is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section.
FAA's Determination and Requirements of This Proposed AD
This product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to our bilateral agreement with the State of Design Authority, we have been notified Start Printed Page 29015of the unsafe condition described in the MCAI and service information referenced above. We are proposing this AD because we evaluated all pertinent information and determined an unsafe condition exists and is likely to exist or develop on other products of the same type design.
Costs of Compliance
We estimate that this proposed AD affects 120 airplanes of U.S. registry.
We estimate the following costs to comply with this proposed AD:
|Action||Labor cost||Parts cost||Cost per product||Cost on U.S. operators|
|Modification||50 work-hours × $85 per hour = $4,250||Up to $478||Up to $4,728||Up to $567,360|
According to the manufacturer, some of the costs of this proposed AD may be covered under warranty, thereby reducing the cost impact on affected individuals. We do not control warranty coverage for affected individuals. As a result, we have included all costs in our cost estimate.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed regulation:
1. Is not a “significant regulatory action” under Executive Order 12866;
2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979);
3. Will not affect intrastate aviation in Alaska; and
4. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.Start List of Subjects
List of Subjects in 14 CFR Part 39
- Air transportation
- Aviation safety
- Incorporation by reference
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:Start Part
PART 39—AIRWORTHINESS DIRECTIVESEnd Part Start Amendment Part
1. The authority citation for part 39 continues to read as follows:End Amendment Part
2. The FAA amends § 39.13 by adding the following new Airworthiness Directive (AD):End Amendment Part
Bombardier, Inc.: Docket No. FAA-2017-0626; Directorate Identifier 2016-NM-210-AD.
(a) Comments Due Date
We must receive comments by August 10, 2017.
(b) Affected ADs
This AD applies to Bombardier, Inc., Model CL-600-2B16 (CL-604 Variant) airplanes, certificated in any category, serial numbers (S/Ns) 5301 through 5665 inclusive, 5701 through 5911 inclusive, 5913, and 5914.
Air Transport Association (ATA) of America Code 22, Autopilot System.
This AD was prompted by reports of in-flight uncommanded rudder movements. We are issuing this AD to prevent in-flight uncommanded rudder movements, which could lead to structural failure and subsequent loss of the airplane.
Comply with this AD within the compliance times specified, unless already done.
Within 48 months after the effective date of this AD: Modify the wiring harness for the yaw damper control system, in accordance with the Accomplishment Instructions of the applicable service information identified in paragraphs (g)(1) and (g)(2) of this AD.
(1) For airplanes having S/Ns 5301 through 5665 inclusive: Bombardier Service Bulletin 604-22-007, Revision 01, dated July 25, 2016.
(2) For airplanes having S/Ns 5701 through 5911 inclusive, 5913, and 5914: Bombardier Service Bulletin 605-22-002, Revision 01, dated July 25, 2016.
(h) Part Installation Limitation
As of the effective date of this AD, no person may install on any airplane a yaw damper actuator having part number 622-9968-002, unless the modification required by paragraph (g) of this AD has been accomplished.
(i) Credit for Previous Actions
This paragraph provides credit for the modification required by paragraph (g) of this AD, if the modification was performed before the effective date of this AD using the applicable service information identified in paragraph (i)(1) or (i)(2) of this AD.
(1) Bombardier Service Bulletin 604-22-007, dated June 23, 2015.
(2) Bombardier Service Bulletin 605-22-002, dated June 23, 2015.
(j) Other FAA AD Provisions
The following provisions also apply to this AD:
(1) Alternative Methods of Compliance (AMOCs): The Manager, New York Aircraft Certification Office (ACO), ANE-170, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to ATTN: The Program Manager, Continuing Operational Safety, FAA, New York ACO, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone 516-228-7300; fax 516-794-5531. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, Start Printed Page 29016the manager of the local flight standards district office/certificate holding district office.
(2) Contacting the Manufacturer: For any requirement in this AD to obtain corrective actions from a manufacturer, the action must be accomplished using a method approved by the Manager, New York ACO, ANE-170, FAA; or Transport Canada Civil Aviation (TCCA); or Bombardier, Inc.,'s TCCA Design Approval Organization (DAO). If approved by the DAO, the approval must include the DAO-authorized signature.
(k) Related Information
(1) Refer to Mandatory Continuing Airworthiness Information (MCAI) Canadian Airworthiness Directive CF-2016-38, dated December 12, 2016, for related information. This MCAI may be found in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017-0626.
(2) For more information about this AD, contact Cesar Gomez, Aerospace Engineer, Airframe and Mechanical Systems Branch, ANE-171, FAA, New York Aircraft Certification Office, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone 516-228-7318; fax 516-794-5531.
(3) For service information identified in this AD, contact Bombardier, Inc., Q-Series Technical Help Desk, 123 Garratt Boulevard, Toronto, Ontario M3K 1Y5, Canada; telephone 416-375-4000; fax 416-375-4539; email email@example.com; Internet http://www.bombardier.com. You may view this service information at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425-227-1221.Start Signature
Issued in Renton, Washington, on June 19, 2017.
John P. Piccola, Jr.,
Acting Manager, Transport Airplane Directorate, Aircraft Certification Service.
[FR Doc. 2017-13364 Filed 6-26-17; 8:45 am]
BILLING CODE 4910-13-P