Federal Aviation Administration (FAA), Department of Transportation (DOT).
Final rule.
The FAA is adopting a new airworthiness directive (AD) for certain EMBRAER Model ERJ 170 airplanes. This AD requires replacing the mini-latches on certain lavatory waste compartment doors with new, stronger latches, and other specified actions. This AD results from reports of certain lavatory waste compartment doors opening during flight due to movement of the waste compartment during takeoff, because the mini-latches installed on the doors of those compartments lose their strength over time. We are issuing this AD to prevent the inability of the waste compartment doors to adequately contain a fire inside the lavatory waste compartment, and consequent uncontained fire and smoke within a lavatory during flight.
This AD becomes effective May 8, 2007.
The Director of the Federal Register approved the incorporation by reference of a certain publication listed in the AD as of May 8, 2007.
You may examine the AD docket on the Internet at
Contact Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343—CEP 12.225, Sao Jose dos Campos—SP, Brazil, for service information identified in this AD.
Todd Thompson, Aerospace Engineer, International Branch, ANM–116, Transport Airplane Directorate, FAA, 1601 Lind Avenue, SW., Renton, Washington 98057–3356; telephone (425) 227–1175; fax (425) 227–1149.
You may examine the AD docket on the Internet at
The FAA issued a supplemental notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to certain EMBRAER Model ERJ 170 airplanes. That supplemental NPRM was published in the
We provided the public the opportunity to participate in the development of this AD. No comments have been received on the supplemental NPRM or on the determination of the cost to the public.
We have carefully reviewed the available data and determined that air safety and the public interest require adopting the AD as proposed in the supplemental NPRM.
The following table provides the estimated costs for U.S. operators to comply with this AD.
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a “significant regulatory action” under Executive Order 12866;
(2) Is not a “significant rule” under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket. See the
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
49 U.S.C. 106(g), 40113, 44701.
(a) This AD becomes effective May 8, 2007.
(b) None.
(c) This AD applies to EMBRAER Model ERJ 170–100 LR, –100 STD, –100 SE, –100 SU, –200 LR, –200 STD, and –200 SU airplanes, certificated in any category; as identified in EMBRAER Service Bulletin 170–25–0024, Revision 01, dated January 9, 2006.
(d) This AD results from reports of certain lavatory waste compartment doors opening during flight due to movement of the waste compartment during takeoff, because the mini-latches installed on those doors lose their strength over time. We are issuing this AD to prevent the inability of the waste compartment doors to adequately contain a fire inside the lavatory waste compartment, and consequent uncontained fire and smoke within a lavatory during flight.
(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.
(f) Within 700 flight hours after the effective date of this AD: Replace the mini-latches for the forward and aft lavatory waste compartment doors by accomplishing all the actions, except for the forward and aft lavatory mirror rework, specified in paragraphs 3.B. and 3.G. of paragraph 4., “Appendix 1,” of EMBRAER Service Bulletin 170–25–0024, Revision 01, dated January 9, 2006.
EMBRAER Service Bulletin 170–25–0024, Revision 01, dated January 9, 2006, refers to C & D Aerospace Service Bulletin 170–18616–25–023, Revision 1, dated November 29, 2005, as an additional source of service information for replacing the mini-latches on certain lavatory waste compartment doors required by paragraph (f) of this AD.
(g) Replacements done before the effective date of this AD in accordance with paragraphs 3.B. and 3.G. of paragraph 4., “Appendix 1,” of EMBRAER Service Bulletin 170–25–0024, dated July 21, 2005, are considered acceptable for compliance with the corresponding action specified in this AD.
(h)(1) The Manager, International Branch, ANM–116, Transport Airplane Directorate, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19.
(2) Before using any AMOC approved in accordance with § 39.19 on any airplane to which the AMOC applies, notify the appropriate principal inspector in the FAA Flight Standards Certificate Holding District Office.
(i) Brazilian airworthiness directive 2005–11–01, effective December 8, 2005, also addresses the subject of this AD.
(j) You must use EMBRAER Service Bulletin 170–25–0024, Revision 01, dated January 9, 2006, to perform the actions that are required by this AD, unless the AD specifies otherwise. The Director of the Federal Register approved the incorporation by reference of this document in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343—CEP 12.225, Sao Jose dos Campos—SP, Brazil, for a copy of this service information. You may review copies at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98057–3356; or at the National Archives and Records Administration (NARA). For information on the availability