Airworthiness Directives; Rolls-Royce Deutschland Ltd & Co KG (RRD) Dart 528, 529, 532, 535, 542, and 552 Series Turboprop Engines
The FAA is superseding an existing airworthiness directive (AD) for RRD Dart 528, 529, 532, 535, 542, and 552 Series turboprop engines. That AD currently requires a dimensional inspection of the intermediate pressure turbine (IPT) disk or an ultrasonic inspection of the seal arm contact between the high pressure turbine (HPT) and the IPT disk seal arm and reworking or replacing the IPT disk if worn beyond acceptable limits. This AD continues to require those actions. This AD results from us including an incorrect engine model and omitting an engine model from the applicability of the existing AD. We are issuing this AD to prevent HPT disk failure, which can result in an uncontained engine failure and damage to the airplane.
1 action from November 2013
- Actions Will Continue Through
Table of Contents Back to Top
- FOR FURTHER INFORMATION CONTACT:
- SUPPLEMENTARY INFORMATION:
- Examining the AD Docket
- Request To Correct a Typographical Error in the Costs of Compliance Section
- Request To Add Airplane Models to the Applicability Paragraph
- Change of Compliance End Dates
- Costs of Compliance
- Authority for This Rulemaking
- Regulatory Findings
- List of Subjects in 14 CFR Part 39
- Adoption of the Amendment
- PART 39—AIRWORTHINESS DIRECTIVES
- Effective Date
- Unsafe Condition
- Intermediate Pressure Turbine (IPT) Disk and High Pressure Turbine (HPT)/IPT Disk Seal Arm Inspections
- Alternative Methods of Compliance
- Related Information
- Material Incorporated by Reference
Tables Back to Top
DATES: Back to Top
This AD becomes effective September 4, 2008. The Director of the Federal Register previously approved the incorporation by reference of certain publications listed in the regulations on February 26, 2007 (72 FR 2610, January 22, 2007).
ADDRESSES: Back to Top
You can get the service information identified in this AD from Rolls-Royce Deutschland Ltd Co KG, Eschenweg 11, D-15827 Dahlewitz, Germany; telephone 49 (0) 33-7086-1768; fax 49 (0) 33-7086-3356.
The Docket Operations office is located at Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue, SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.
FOR FURTHER INFORMATION CONTACT: Back to Top
Jason Yang, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; telephone (781) 238-7747; fax (781) 238-7199.
SUPPLEMENTARY INFORMATION: Back to Top
The FAA proposed to amend 14 CFR part 39 by superseding AD 2007-02-07, Amendment 39-14894 (72 FR 2610, January 22, 2007), with a proposed AD. The proposed AD applies to RRD Dart 528, 529, 532, 535, 542, and 552 Series turboprop engines. We published the proposed AD in the Federal Register on November 9, 2007 (72 FR 63508). That action proposed to require deleting the Dart 555 series engines from the applicability paragraph of the proposed AD, and to list the Dart 552 series turboprop engines in the applicability paragraph of the proposed AD.
Examining the AD Docket Back to Top
You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
Comments Back to Top
We provided the public the opportunity to participate in the development of this AD. We have considered the comments received.
Request To Correct a Typographical Error in the Costs of Compliance Section Back to Top
One commenter asks us to change “turbofan engines” in the Costs of Compliance Section to “turboprop engines.” The commenter states that the Dart engine is a turboprop engine, not a “turbofan engines.”
We agree. We changed “turbofan engines” in the Costs to Comply section to “turboprop engines.”
Request To Add Airplane Models to the Applicability Paragraph Back to Top
The same commenter states that paragraph (c) Applicability, appears to omit some models of airplanes that might use the engines. The commenter states that the Dart engine is installed by supplemental type certificate on certain General Dynamics Convair model airplanes, and that those airplanes can still be found in the FAA's registry database.
We partially agree. We must identify in paragraph (c) Applicability, all engine models that are affected by this AD. We list the aircraft models that might use those engines to help readers to determine if they might have an affected engine. However, for clarity, we have changed the applicability paragraph to include the General Dynamics Convair models that might use these engines under supplemental type certificates.
Change of Compliance End Dates Back to Top
We changed the compliance end dates in paragraphs (f)(2)(i) from June 30, 2007, to June 30, 2008, and paragraph (f)(2)(ii) from April 30, 2008, to July 31, 2008. We changed the compliance dates to avoid unnecessary grounding of aircraft while still meeting our safety concerns.
Conclusion Back to Top
We have carefully reviewed the available data, including the comments received, and determined that air safety and the public interest require adopting the AD with the changes described previously. We have determined that these changes will neither increase the economic burden on any operator nor increase the scope of the AD.
Costs of Compliance Back to Top
We estimate that this AD will affect 30 RRD Dart 528, 529, 532, 535, 542, and 552 series turboprop engines installed on airplanes of U.S. registry. We also estimate that it will take about 50 work-hours per engine to perform the proposed actions, and that the average labor rate is $80 per work-hour. Required parts will cost about $50,000 per IPT disk. We estimate that 25 percent, or eight engines, will require IPT disk replacement. Based on these figures, we estimate the total cost of the AD to U.S. operators to be $500,000.
Authority for This Rulemaking Back to Top
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, section 44701, “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings Back to Top
We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a “significant regulatory action” under Executive Order 12866;
(2) Is not a “significant rule” under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and placed it in the AD Docket. You may get a copy of this summary at the address listed under ADDRESSES.
Adoption of the Amendment Back to Top
Accordingly, under the authority delegated to me by the Administrator, the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39—AIRWORTHINESS DIRECTIVES Back to Top
1.The authority citation for part 39 continues to read as follows:
§ 39.13 [Amended]
2.The FAA amends § 39.13 by removing Amendment 39-14894 (72 FR 2610, January 22, 2007), and by adding a new airworthiness directive, Amendment 39-15623, to read as follows:
2008-16-05Rolls-Royce Deutschland Ltd Co KG (formerly Rolls-Royce plc): Amendment 39-15623. Docket No. FAA-2006-24825; Directorate Identifier 2006-NE-17-AD.
Effective Date Back to Top
(a) This airworthiness directive (AD) becomes effective September 4, 2008.
(b) This AD supersedes AD 2007-02-17, Amendment 39-14894.
Applicability Back to Top
(c) This AD applies to Rolls-Royce Deutschland Ltd Co KG (RRD) Dart 528, 529, 532, 535, 542, and 552 series turboprop engines. These engines are installed on, but not limited to, Hawker Siddeley, Argosy AW.650, Fairchild Hiller F-27, F-27A, F-27B, F-27F, F-27G, F-27J, FH-227, FH-227B, FH-227C, FH-227D, FH-227E, Fokker F.27 all marks; British Aircraft Corporation Viscount 744, 745D and 810; Gulfstream G-159, General Dynamics Convair 240D or 600, or 600-240D, and 340D or 440D, or 640-340D and 640-440D airplanes.
Unsafe Condition Back to Top
(d) This AD results from us including an incorrect engine model and omitting an engine model from the applicability of the existing AD. We are issuing this AD to prevent HPT disk failure, which can result in an uncontained engine failure and damage to the airplane.
Compliance Back to Top
(e) You are responsible for having the actions required by this AD performed within the compliance times specified unless the actions have already been done.
Intermediate Pressure Turbine (IPT) Disk and High Pressure Turbine (HPT)/IPT Disk Seal Arm Inspections Back to Top
(f) Within 60 days after the effective date of the AD, do either of the following:
(1) Perform a dimensional inspection of the IPT disk and repair or replace the IPT disk, if necessary using paragraph 3 of the Accomplishment Instructions of RRD service bulletin (SB) Da72-538, dated June 10, 2005; or
(2) Perform an ultrasonic inspection of the disk seal arm contact between the HPT and the IPT using paragraph 3 of the Accomplishment Instructions of RRD SB Da72-536, Revision 1, dated August 25, 2003.
(i) For RRD Dart 528, 529, 532, 535, 542 series turboprop engines if wear is outside allowable limits, before June 30, 2008, perform a dimensional inspection and repair or replace the IPT disk, if necessary. Use paragraph 3 of the Accomplishment Instructions of RRD SB Da72-538, dated June 10, 2005.
(ii) For RRD Dart 552 series turboprop engines if wear is outside allowable limits, before July 31, 2008, perform a dimensional inspection and repair or replace the IPT disk, if necessary. Use paragraph 3 of the Accomplishment Instructions of RRD SB Da72-538, dated June 10, 2005.
(iii) If wear is within allowable limits, perform a dimensional inspection of the IPT disk at the next engine shop visit or at next overhaul, whichever occurs first and repair or replace the IPT disk, if necessary. Use paragraph 3 of the Accomplishment Instructions of RRD SB Da72-538, dated June 10, 2005.
Alternative Methods of Compliance Back to Top
(g) The Manager, Engine Certification Office, has the authority to approve alternative methods of compliance for this AD if requested using the procedures found in 14 CFR 39.19.
Related Information Back to Top
(h) LBA airworthiness directive D-2005-197, dated June 30, 2005, also addresses the subject of this AD.
(i) Contact Jason Yang, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; telephone (781) 238-7747, fax (781) 238-7199; e-mail: firstname.lastname@example.org, for more information about this AD.
Material Incorporated by Reference Back to Top
(j) You must use the Rolls-Royce Deutschland Ltd Co KG service information specified in Table 1 to perform the actions required by this AD. The Director of the Federal Register previously approved the incorporation by reference of the service information specified in Table 1 on February 26, 2007 (72 FR 2610, January 22, 2007). Contact Rolls-Royce Deutschland Ltd Co KG, Eschenweg 11, D-15827 Dahlewitz, Germany; telephone 49 (0) 33-7086-1768; fax 49 (0) 33-7086-3356 for a copy of this service information. You may review copies at the FAA, New England Region, 12 New England Executive Park, Burlington, MA; or at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.
|Service Bulletin No.||Page||Revision||Date|
|Da72-536: Total Pages: 23||All||1||August 25, 2003.|
|Da72-538: Total Pages: 21||All||Original||June 10, 2005.|
Issued in Burlington, Massachusetts, on July 24, 2008.
Acting Manager, Engine and Propeller Directorate, Aircraft Certification Service.
[FR Doc. E8-17423 Filed 7-30-08; 8:45 am]
BILLING CODE 4910-13-P