Skip to Content

Rule

Airworthiness Directives; Dornier Model 328-100 Series Airplanes

Document Details

Information about this document as published in the Federal Register.

Published Document

This document has been published in the Federal Register. Use the PDF linked in the document sidebar for the official electronic format.

Start Preamble Start Printed Page 4353

AGENCY:

Federal Aviation Administration, DOT.

ACTION:

Final rule.

SUMMARY:

This amendment adopts a new airworthiness directive (AD), applicable to certain Dornier Model 328-100 series airplanes, equipped with ground spoiler actuators having part number 1059A0000-02, that requires removal of the gland attachment bolts of the ground spoiler actuator and replacement with new bolts installed with higher torque. This amendment is prompted by issuance of mandatory continuing airworthiness information by a foreign civil airworthiness authority. The actions specified by this AD are intended to prevent hydraulic fluid leakage due to loose or broken gland attachment bolts, and consequent loss of the main hydraulic system.

DATES:

Effective March 2, 2000.

The incorporation by reference of certain publications listed in the regulations is approved by the Director of the Federal Register as of March 2, 2000.

ADDRESSES:

The service information referenced in this AD may be obtained from FAIRCHILD DORNIER, DORNIER Luftfahrt GmbH, P.O. Box 1103, D-82230 Wessling, Germany. This information may be examined at the Federal Aviation Administration (FAA), Transport Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

Start Further Info

FOR FURTHER INFORMATION CONTACT:

Norman B. Martenson, Manager, International Branch, ANM-116, FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 227-2110; fax (425) 227-1149.

End Further Info End Preamble Start Supplemental Information

SUPPLEMENTARY INFORMATION:

A proposal to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to include an airworthiness directive (AD) that is applicable to Dornier Model 328-100 series airplanes, equipped with ground spoiler actuators having part number 1059A0000-02, was published in the Federal Register on November 26, 1999 (64 FR 66422). That action proposed to require removal of the gland attachment bolts of the ground spoiler actuator and replacement with new bolts installed with higher torque.

Comments

Interested persons have been afforded an opportunity to participate in the making of this amendment. No comments were submitted in response to the proposal or the FAA's determination of the cost to the public.

Conclusion

The FAA has determined that air safety and the public interest require the adoption of the rule as proposed.

Cost Impact

The FAA estimates that 12 airplanes of U.S. registry will be affected by this AD, that it will take approximately 2 work hours per airplane to accomplish the required replacement, and that the average labor rate is $60 per work hour. Required parts will be provided at no cost to the operator. Based on these figures, the cost impact of the AD on U.S. operators is estimated to be $1,440, or $120 per airplane.

The cost impact figure discussed above is based on assumptions that no operator has yet accomplished any of the requirements of this AD action, and that no operator would accomplish those actions in the future if this AD were not adopted.

Regulatory Impact

The regulations adopted herein will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, it is determined that this final rule does not have federalism implications under Executive Order 13132.

For the reasons discussed above, I certify that this action (1) is not a “significant regulatory action” under Executive Order 12866; (2) is not a “significant rule” under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption ADDRESSES.

Start List of Subjects

List of Subjects in 14 CFR Part 39

End List of Subjects

Adoption of the Amendment

Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

Start Part

PART 39—AIRWORTHINESS DIRECTIVES

End Part Start Amendment Part

1. The authority citation for part 39 continues to read as follows:

End Amendment Part Start Authority

Authority: 49 U.S.C. 106(g), 40113, 44701.

End Authority
[Amended]
Start Amendment Part

2. Section 39.13 is amended by adding the following new airworthiness directive:

End Amendment Part

2000-02-08 DORNIER LUFTFAHRT GMBH: Amendment 39-11527. Docket 99-NM-219-AD.

Applicability: Model 328-100 series airplanes, equipped with ground spoiler actuators having part number 1059A0000-02, certificated in any category.

Note 1:

This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (c) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.

Compliance: Required as indicated, unless accomplished previously.

To prevent hydraulic fluid leakage due to loose or broken gland attachment bolts, and consequent loss of the main hydraulic system, accomplish the following:

Replacement

(a) Prior to the accumulation of 3,300 total flight hours, or within 330 flight hours after the effective date of this AD, whichever occurs later, remove the four gland attachment bolts of the ground spoiler actuator and replace with new bolts installed at a higher torque, in accordance with Dornier Service Bulletin SB-328-27-289, dated March 3, 1999.

Note 2:

Dornier Service Bulletin SB-328-27-289, dated March 3, 1999, refers to Liebherr Service Bulletin 1059A-27-01, dated March 5, 1999, as an additional source of service information for accomplishment of the replacement.

Start Printed Page 4354

Spares

(b) As of the effective date of this AD, no person shall install, on any airplane, a ground spoiler actuator having part number 1059A0000-02, unless it has been modified in accordance with Dornier Service Bulletin SB-328-27-289, dated March 3, 1999.

Alternative Methods of Compliance

(c) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, International Branch, ANM-116, FAA, Transport Airplane Directorate. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, International Branch, ANM-116.

Note 3:

Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the International Branch, ANM-116.

Special Flight Permits

(d) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished.

Incorporation by Reference

(e) The replacement shall be done in accordance with Dornier Service Bulletin SB-328-27-289, dated March 3, 1999. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from FAIRCHILD DORNIER, DORNIER Luftfahrt GmbH, P.O. Box 1103, D-82230 Wessling, Germany. Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

Note 4:

The subject of this AD is addressed in German airworthiness directive 1999-175, dated June 3, 1999.

(f) This amendment becomes effective on March 2, 2000.

Start Signature

Issued in Renton, Washington, on January 20, 2000.

Donald L. Riggin,

Acting Manager, Transport Airplane Directorate, Aircraft Certification Service.

End Signature End Supplemental Information

[FR Doc. 00-1768 Filed 1-26-00; 8:45 am]

BILLING CODE 4910-13-U