Skip to Content

Notice

In the Matter of J.L. Shepard & Associates, San Fernando, CA; Confirmatory Order Relaxing Order (Effective Immediately)

Document Details

Information about this document as published in the Federal Register.

Published Document

This document has been published in the Federal Register. Use the PDF linked in the document sidebar for the official electronic format.

Start Preamble

I

J.L. Shepherd & Associates (JLS&A) was the holder of Quality Assurance (QA) Program Approval for Radioactive Material Packages No. 0122 (Approval No. 0122), issued by the U.S. Nuclear Regulatory Commission (NRC or Commission) pursuant to 10 CFR part 71, subpart H. QA activities authorized by Approval No. 0122 include: design, procurement, fabrication, assembly, testing, modification, maintenance, repair, and use of transportation packages subject to the provisions of 10 CFR part 71. Approval No. 0122 was originally issued January 17, 1980. In addition to having a QA program approved by the NRC to satisfy the provisions of 10 CFR part 71, subpart H, to transport or deliver for transport licensed material in a package, JLS&A is required by 10 CFR part 71, Subpart C, to have and comply with the package's Certificate of Compliance (CoC) issued by the NRC. Based on JLS&A's failure to comply with 10 CFR part 71, QA Program Approval No. 0122 was withdrawn, by the immediately effective NRC Order, dated July 3, 2001, (66 FR 36603, July 12, 2001).

II

The NRC lacked confidence that JLS&A would implement the QA Program approved by the NRC in accordance with 10 CFR part 71, Subpart H, in a manner that would assure the required preparation and use of transportation packages in full conformance with the terms and conditions of an NRC CoC and with 10 CFR part 71. JLS&A's QA Approval No. 0122 was withdrawn by an immediately effective Order issued July 3, 2001, (July 2001 Order).

By letters dated August 16, and September 13, 2001, JLS&A responded to the July 2001 Order, and requested Start Printed Page 16458that provisions of the Order be relaxed based on a showing of good cause. Specifically, JLS&A requested interim relief from the July 2001 Order based on JLS&A's proposed Near-Term Corrective Action Plan, to allow 68 shipments to 16 customers, in U.S. Department of Transportation specification packaging designated as 20WC. The NRC issued a Confirmatory Order Relaxing Order, dated September 19, 2001 (66 FR 49708, September 28, 2001), granting interim relief to allow 68 shipments to 16 customers in 20 WC packages in accordance with JLS&A's Near-Term Corrective Action Plan, through March 2002, provided JLS&A's satisfactory completion of certain commitments.

By letters dated December 7 and 10, 2001, JLS&A requested that provisions of the July 2001 Order be relaxed based on a showing of good cause. Specifically, JLS&A requested interim relief to ship an irradiator to Surry Nuclear Power Station and return the replaced unit to JLS&A's facility in California. JLS&A proposed to use the Near-Term Corrective Action Plan specified in the September 19, 2001, Confirmatory Order to allow these two shipments in U.S. Department of Transportation specification packaging designated as 20WC. The NRC issued a Confirmatory Order Relaxing Order dated December 13, 2001 (66 FR 67556, December 31, 2001), granting interim relief to allow two shipments to one customer in 20 WC packages in accordance with JLS&A's Near Term Corrective Action Plan, provided JLS&A's satisfactory completion of certain commitments.

III

By letters dated February 26, 2002, as supplemented March 13, 18, and 25, 2002, JLS&A requested that provisions of the July 2001 Order be further relaxed based on a showing of good cause. Specifically, JLS&A requested an extension of the shipment period authorized in the September 19, 2001, Order from March 31, 2002, to June 30, 2002, to allow JLS&A to complete shipment of Type B quantities of radioactive material in U. S. Department of Transportation 20WC specification packaging that was authorized by the September 19, 2001, Order. This extension of the expiration date is necessary since many of the customers did not obtain the necessary licensing approvals or to complete needed facility modifications to possess the radioactive material in time for the shipments to be completed by March 31, 2002. In addition, JLS&A requested authorization to make additional shipments to customers not approved by the September 19, 2001, Order. JLS&A proposes to use the Near-Term Corrective Action Plan specified in the September 19, 2001, Confirmatory Order. JLS&A committed to: (1) Inspect the 20WC package (both shield and overpack); (2) document the inspection in a separate report; (3) perform the shipping and inspection function only by trained personnel; and (4) have the Independent Auditor verify compliance of each shipment with the foregoing commitments and certify such compliance in the monthly reports to the NRC.

In addition, on February 26, 2002, JLS&A consented to issuance of this Confirmatory Order granting interim relief from the July 2001 Order subject to the foregoing commitments, as set forth in Section IV below, and agreed that this Confirmatory Order is to be effective upon issuance, and agreed to waive its right to a hearing on this action. Implementation of these commitments will provide assurance that sufficient resources will be applied to the QA program, and that the program will be conducted safely and in accordance with NRC requirements.

I find that JLS&A's commitments as set forth in Section IV are acceptable and necessary and conclude that with these commitments the public health and safety are reasonably assured. The NRC staff reviewed JLS&A's relief request to determine whether to grant the requested relief with assurances that public health and safety are maintained. In view of the foregoing, I have determined that the public health and safety require that JLS&A's commitments be confirmed by this Confirmatory Order. This Confirmatory Order only grants additional time to complete the shipments previously authorized by the September 30, 2001, Order. Based on the above and JLS&A's consent, this Confirmatory Order is effective immediately upon issuance.

IV

Accordingly, pursuant to Sections 62, 81, 161b, 161i, 182 and 186 of the Atomic Energy Act of 1954, as amended, and the Commission's regulations in 10 CFR Section 2.202 and 10 CFR parts 71 and 110, it is hereby ordered, effective immediately, that the July 3, 2001, order is relaxed to grant interim relief, through June 30, 2002, to complete shipments to customers previously authorized by the September 30, 2001 order and identified in enclosure 1 to the March 14, 2002 supplement entitled “NT-CAP1: Shipments Contracted for Prior to July 3, 2001”, in accordance with JLS&As near-term corrective action plan, provided:

1. JLS&A uses the implementing procedures for the 1995 QA program plan, as revised, and the Near-Term Corrective Action Plan to complete an inspection of the 20WC packages involved in the shipments. The inspection will confirm that the packages and associated procedures are in conformance with 49 CFR 178.362, “Specification 20WC wooden protective jacket.” Each inspection will include, at a minimum, actual physical measurements, and visual inspections for damage, corrosion, or other potentially unacceptable conditions;

2. JLS&A documents the results of each inspection in separate reports approved by the QA Administrator and prepared in accordance with the revised 1995 QA program plan and implementing procedures. The report will include the list of attributes verified, the acceptance criteria, and the results for each attribute;

3. JLS&A uses JLS&A's staff, contractors, and sub-contractors, trained in the Near-Term Corrective Action Plan and the revised 1995 QA program plan and implementing procedures for conducting the inspections listed in the above condition; and,

4. JLS&A uses the Independent Auditor to ensure that the three conditions listed above have been completed. Additionally, the Independent Auditor shall conduct monthly QA program audits and will provide NRC with a report by the 20th of each month. The Independent Auditor shall verify the compliance of each shipment with the three Conditions listed above and certify to the Commission in its monthly reports.

The Director, Office of Enforcement, or the Director, Office of Nuclear Material Safety and Safeguards, may in writing, relax or rescind this Confirmatory Order upon demonstration of good cause by the JLS&A.

V

In accordance with 10 CFR 2.202, any person, other than JLS&A, adversely affected by this Confirmatory Order may request a hearing within 20 days of its issuance.

Where good cause is shown, consideration will be given to extending the time to request a hearing. A request for extension of time must be made in writing to the Director, Office of Enforcement, U.S. Nuclear Regulatory Commission, Washington, DC 20555, and include a statement of good cause for the extension. Any request for a hearing shall be submitted to the Secretary, U.S. Nuclear Regulatory Commission, ATTN: Rulemakings and Adjudications Staff, Washington, DC Start Printed Page 1645920555. Copies of the hearing request also should be sent to the Director, Office of Enforcement, U.S. Nuclear Regulatory Commission, Washington, DC 20555, to the Director, Office of Nuclear Material Safety and Safeguards at the same address, to the Assistant General Counsel for Materials Litigation and Enforcement at the same address, to the Regional Administrator, NRC Region IV, 611 Ryan Plaza Drive, Suite 400, Arlington, TX 76011, and to JLS&A. If such person requests a hearing, that person shall set forth with particularity the manner in which his or her interest is adversely affected by this Confirmatory Order and shall address the criteria set forth in 10 CFR 2.714(d).

If a hearing is requested by a person whose interest is adversely affected, the Commission will issue an Order designating the time and place of any hearing. If a hearing is held, the issue to be considered at such hearing shall be whether this Confirmatory Order should be sustained.

In the absence of any request for hearing, or written approval of an extension of time in which to request a hearing, the provisions specified in Section IV above shall be final 20 days from the date of this Confirmatory Order without further Order or proceedings. If an extension of time for requesting a hearing has been approved, the provisions specified in Section IV shall be final when the extension expires if a hearing request has not been received.

A request for hearing shall not stay the immediate effectiveness of this confirmatory order.

Start Signature

Dated this 29th day of March 2002.

For the Nuclear Regulatory Commission.

James G. Luehman,

Deputy Director, Office of Enforcement.

End Signature End Preamble

[FR Doc. 02-8244 Filed 4-4-02; 8:45 am]

BILLING CODE 7590-01-P