Skip to Content

We invite you to try out our new beta eCFR site at We’ve made big changes to make the eCFR easier to use. Be sure to leave feedback using the 'Feedback' button on the bottom right of each page!


Department of Defense Commercial Air Transportation Quality and Safety Review Program

Document Details

Information about this document as published in the Federal Register.

Document Statistics
Document page views are updated periodically throughout the day and are cumulative counts for this document. Counts are subject to sampling, reprocessing and revision (up or down) throughout the day.
Published Document

This document has been published in the Federal Register. Use the PDF linked in the document sidebar for the official electronic format.

Start Preamble


Department of the Air Force, DOD.


Final rule.


The Department of the Air Force has revised the Department of Defense Commercial Transportation Quality and Safety Review Program. This was necessary to reflect current and anticipated policies.


October 29, 2002.

Start Further Info


Mr. Merlin Lyman, 618-229-4801.

End Further Info End Preamble Start Supplemental Information


This action is authorized by 10 U.S.C. 8013 and 10 U.S.C. 2640. The Department of the Air Force has determined that this rule is not a major rule because it will not have an annual effect on the economy of $100 million or more. The Secretary of the Air Force has certified that this rule is exempt from the requirements of the Regulatory Flexibility Act, 5 U.S.C. 601 to 612, because this rule does not have a significant economic impact on small entities as defined by the Act, and does not impose any obligatory information requirements beyond internal Air Force use.

Start List of Subjects

List of Subjects in 32 CFR Part 861

  • Administrative practice and procedure
  • Air carriers
  • Aviation safety
  • Military air transportation
End List of Subjects Start Amendment Part

For the reasons set forth in the preamble, the Air Force has revised 32 CFR Part 861 to read as follows:

End Amendment Part Start Part


DOD commercial air transportation quality and safety review program.
DOD Commercial Airlift Review Board procedures.
DOD review of foreign air carriers.
Disclosure of voluntarily provided safety-related information.
Start Authority

Authority: 10 U.S.C. 2640, 8013.

End Authority
Start Printed Page 65699

The following references apply to this part:

(a) 10 U.S.C. 2640, Charter Air Transportation of Members of the Armed Forces.

(b) Department of Defense Directive 4500.53, Department of Defense Commercial Air Transportation Quality and Safety Review Program.


Department of Defense Directive 4500.53, Department of Defense Commercial Air Transportation Quality and Safety Review Program, charges the Commander-in-Chief (CINC), United States Transportation Command (USTRANSCOM), with ensuring the establishment of safety requirements and criteria for evaluating civil air carriers and operators (hereinafter collectively referred to as “air carriers”) providing air transportation and operational support services to the Department of Defense (DOD). It also charges the CINC with ensuring the establishment of a Commercial Airlift Review Board (CARB) and providing policy guidance and direction for its operation. This part establishes DOD quality and safety criteria for air carriers providing or seeking to provide air transportation and, at the discretion of the CARB or higher authority, operational support services to the DOD. This part also includes the operating procedures of the CARB. The CARB has the authority to suspend air carriers from DOD use or take other actions when issues of air carrier quality and air safety arise.


(a) Air carrier. Individuals or entities that operate commercial fixed and rotary wing aircraft in accordance with the Federal Aviation Regulations (14 CFR Chapter I) or equivalent regulations issued by a country's Civil Aviation Authority (CAA) and which provide air transportation or operational support services. Commercial air carriers under contract with, or operating on behalf of the DOD shall have a FAA or CAA certificate.

(b) Air transportation services. The transport of DOD personnel or cargo by fixed or rotary wing commercial aircraft, where such services are acquired primarily for the transportation of DOD personnel and cargo, through donation or any form of contract, tender, blanket ordering agreement, Government charge card, Government or commercial transportation request (TR), bill of lading, or similar instruments. Air transportation services also include medical evacuation services, paratrooper drops, and charter airlift and group travel arranged by the Military Service Academies, foreign military sales, nonappropriated fund instrumentalities by other DOD and non-DOD activities for DOD personnel. All air carriers providing air transportation services to DOD must have a FAA or CAA certificate. The policy contained in this Directive shall not apply to individually procured, discretionary air travel, such as that associated with military leave or pass.

(c) Civil Aviation Authority (CAA). The CAA refers to the organization within a country that has the authority and responsibility to regulate civil aviation. The term CAA is used throughout this part since these requirements are applicable to both U.S. and foreign carriers doing business with DOD. The term CAA thus includes the U.S. Federal Aviation Administration (FAA).

(d) Code sharing. Code sharing is a marketing arrangement in which an air carrier places its designator code on a flight operated by another air carrier and sells tickets for that flight.

(e) DOD approval. DOD approval in the context of this part refers to the process by which air carriers seeking to provide passenger or cargo airlift services (hereinafter referred to as air transportation services) to the DOD must be screened and evaluated by the DOD Air Carrier Survey and Analysis Office or other entity authorized by the CARB, and approved for DOD use by the CARB. Once initial approval is obtained, a DOD approved air carrier must remain in an approved status to be eligible for DOD business. Although not generally required, the CARB or higher authority may, on a case-by-case basis, require DOD approval of air carriers providing operational support services to DOD.

(f) DOD air carrier safety and quality review process. Includes four possible levels of review with increasing authority. The responsibilities of each are described in more detail in the reference in § 861.1 (b). These levels consist of the:

(1) DOD Air Carrier Survey and Analysis Office;

(2) DOD Commercial Airlift Review Board (CARB);

(3) Commander-in-Chief, U.S. Transportation Command, or USCINCTRANS; and

(4) Secretary of Defense. (Note: A DOD-level body, the Commercial Airlift Review Authority, or CARA, provides advice and recommendations to the Secretary of Defense.)

(g) Federal Aviation Administration (FAA) International Safety Assessment (IASA) program and categories. The FAA IASA program assesses the ability of a foreign country's CAA to adhere to international standards established by the United Nation's technical agency for aviation, the International Civil Aviation Organization (ICAO). The FAA has established ratings for the status of countries as follows:

(1) Category 1—Does comply with ICAO standards. A country's CAA has been found to license and oversee air carriers in accordance with ICAO aviation safety standards.

(2) Category 2—Does not comply with ICAO standards. A country's CAA does not meet ICAO standards for aviation oversight. Operations to the U.S. by a carrier from a Category 2 country are limited to those in effect at the time a country is classified as Category 2 and are subjected to heightened FAA surveillance. Expansion or changes in services to the U.S. are not permitted while a country is in Category 2 status unless the carrier arranges to have new services conducted by an air carrier from a Category 1 country. Category 2 countries that do not have operations to the U.S. at the time of the FAA assessment are not permitted to commence such operations unless it arranges to have its flights conducted by an air carrier from a Category 1 country.

(3) Non-rated. A country's CAA is labeled “non-rated” if it has not been assessed by the FAA.

(h) GSA City Pair Program. A program managed by the General Services Administration in which U.S. air carriers compete for annual contracts awarding U.S. Government business for specific domestic and international scheduled service city pair routes.

(i) Group travel. Twenty-one or more passengers on orders from the same organization traveling on the same date to the same destination to attend the same function.

(j) Letter of Warning. A notice to a DOD approved air carrier of a failure to satisfy safety or airworthiness requirements which, if not remedied, may result in temporary nonuse or suspension of the air carrier by the DOD. Issuance of a Letter of Warning is not a prerequisite to a suspension or other action by the CARB or higher DOD authority.

(k) On-site Capability Survey. The most comprehensive evaluation performed by DOD's Air Carrier Survey and Analysis Office. Successful completion of this evaluation is required of most air carriers before they may be approved to provide air transportation services to DOD. Once approved, air carriers are subject to periodic On-site Capability Surveys, as Start Printed Page 65700specified at Enclosure 3 in the reference in § 861.1(b).

(l) Operational support services. Missions performed by air carriers that use fixed or rotary-winged aircraft to provide services other than air transportation services as defined in paragraph (b) of this section. Examples include, but are not limited to, range instrumentation and services, target-towing, sling loads, and electronic countermeasures target flights. Air carriers providing only operational support services do not require advance DOD approval and are not subject to the initial or periodic on-site survey requirements under this part, unless directed by the CARB or higher authority. All air carriers providing operational support services to DOD must have a FAA or CAA certificate and are required to maintain applicable FAA or CAA standards absent deviation authority obtained pursuant to 14 CFR 119.55 or similar CAA rules.

(m) Performance assessments. Reviews conducted by U.S. air carriers when evaluating foreign air carriers with which they have code share arrangements, using performance-based factors. Such assessments include reviewing a variety of air carrier data including history, safety, scope/size, financial condition, equipment, flight operations and airworthiness issues.

(n) Performance evaluations. Reviews conducted by DOD as directed in the references in § 861.1(a) and (b). These evaluations include a review of air carrier flight operations, maintenance departments, safety programs and other air carrier areas as necessary. Performance evaluations are not conducted on-site, but rely on information collected primarily from the FAA and the National Transportation Safety Board (NTSB).

(o) Preflight safety inspection. A visual safety inspection of the interior and exterior of an air carrier's aircraft performed by DOD personnel in accordance with the references in § 861.1(a) and (b).

(p) Suspension. The exclusion of an air carrier from providing services to the DOD. The period of suspension will normally:

(1) Remain in effect until the air carrier furnishes satisfactory evidence that the conditions causing the suspension have been remedied and has been reinstated by the CARB, or;

(2) Be for a fixed period of time as determined at the discretion of the CARB.

(q) Temporary nonuse. The immediate exclusion of a DOD approved air carrier from providing services to the DOD pending a decision on suspension. Normally, temporary nonuse will be for a period of 30 days or less. However, by mutual agreement of the CARB and the air carrier involved, a suspension hearing or decision may be delayed and the air carrier continued in a temporary nonuse status for an extended period of time.

(r) Voluntarily provided safety-related information. Information which consists of nonfactual safety-related data, reports, statements, and other information provided to DOD by an air carrier at any point in the evaluation process described in this Part. It does not include factual safety-related information, such as statistics, maintenance reports, training records, flight planning information, and the like.

DOD air transportation quality and safety requirements.

(a) General. The DOD, as a customer of air transportation and operational support services, expects air carriers used by DOD to employ programs and business practices that not only ensure good service but also enhance the safety, operational, and maintenance standards established by applicable Civil Aviation Authority (CAA) regulations. Accordingly, and as required by the references in § 861.1 (a) and (b), the DOD has established a set of quality and safety criteria and requirements that reflect the type programs and practices DOD seeks from air carriers providing services to DOD. Air carriers must meet and maintain these requirements in order to be eligible for DOD business. Air carriers providing air transportation services to DOD either directly by contract or agreement, or indirectly through the General Services Administration (GSA) City Pair Program or some other arrangement, must be approved by DOD prior to providing such services and remain in an approved status throughout the contract, agreement, or arrangement performance period. This approval entails successful completion of initial and recurring on-site surveys as well as periodic performance evaluations in accordance with the reference in § 861.1(b). The quality and safety criteria and requirements set forth in this part complement rather than replace the CAA criteria applicable to air carriers. Air carriers normally remain fully subject to applicable CAA regulations (CARs) while performing business for the DOD, even when the aircraft involved is used exclusively for DOD missions. The inspection and oversight criteria set forth in this part do not, as a general rule, apply to air carriers providing only operational support services to DOD. However, in the event concerns relating to the safety of such a carrier arise, the CARB or higher authority may, on a case-by-case basis, direct an appropriate level of oversight under the authority of this part.

(b) Applicability. (1) The evaluation, quality and safety criteria and requirements set forth in this part apply to air carriers providing or seeking to provide air transportation services to DOD.

(2) Foreign air carriers performing portions of GSA City Pair routes awarded to U.S. air carriers under a code-sharing arrangement, as well as foreign air carriers providing individually-ticketed passenger service to DOD personnel traveling on official business, may be subject to limited oversight and review pursuant to § 861.6.

(3) The inspection and oversight requirements, as well as the quality and safety criteria of this part may, on a case-by-case basis and at the discretion of the CARB or higher authority, be applied to air carriers seeking to provide or providing operational support services as defined in § 861.3(l).

(4) The inspection and oversight requirements of this part do not apply to aircraft engaged in medical transport services if procured under emergency conditions to save life, limb or eyesight. Likewise, the inspection and oversight requirements of this part are not applicable when DOD is not involved in the procurement of the medical transportation services. For example, when specific medical treatment is obtained on an individual basis by or for DOD personnel with medical transportation provided, as needed, at the direction of the non-DOD medical care giver. This includes situations where DOD, through TRICARE or otherwise, pays for such transportation as part of the costs of medical services provided.

(c) Scope and nature of the evaluation program—(1) Evaluation requirement. The provision of air transportation services under a contract or agreement with or on behalf of DOD, requires the successful completion of an initial on-site survey and approval by the CARB under this part in order to be eligible for DOD business. In addition, U.S. air carriers awarded contracts under the GSA City Pair Program, including those that perform part of the contract under a code-sharing arrangement with the U.S. air carrier awarded the contract, must successfully complete an initial on-site survey and be approved by the CARB for DOD use under this part prior to beginning performance of the GSA contract. Once approved by DOD, air Start Printed Page 65701carriers providing air transportation services are subject to recurring on-site surveys and performance evaluations and assessments throughout the duration of the relevant contract or agreement. The frequency and scope of these surveys and performance reviews will be in accordance with Enclosure 3 of the reference in § 861.1(b).

(2) Office of primary responsibility. Evaluations are performed by the DOD Air Carrier Survey and Analysis Office located at Scott Air Force Base, Illinois. The mailing address of this office is HQ AMC/DOB, 402 Scott Drive Unit 3A1, Scott AFB IL 62225-5302. The website address is​hqamc/​dob/​index.htm.

(3) Items considered in the evaluation process. The specifics of the applicable DOD contract or agreement (if any), the applicable CAA regulations, and the experienced judgment of DOD personnel will be used to evaluate an air carrier's capability to perform services for DOD. The survey may also include, with the air carrier's coordination, observation of cockpit crew performance, as well as ramp inspections of selected company aircraft. In the case of air carriers seeking to provide air transportation services, after satisfactory completion of the initial survey and approval by the CARB as a DOD air carrier, follow-up surveys will be conducted on a recurring basis and when otherwise required to validate adherence to DOD quality and safety requirements. DOD personnel will also assess these quality and safety requirements when conducting periodic air carrier performance evaluations. The size of an air carrier, along with the type and scope of operations will be considered during the on-site survey. For example, while an air taxi operator may not have a formal flight control function, such as a 24-hour dispatch organization, that same air taxi operator is expected to demonstrate some type of effective flight following capability. On the other hand, a major air carrier is expected to have a formal flight control or dispatch function. Both, however, will be evaluated based on the effectiveness and quality of whatever flight following function they do maintain. In the case of air carriers seeking to provide operational support services, the type, scope and frequency of evaluation, if any, performed by DOD or other entity will be as directed by the CARB or higher authority.

(d) Status of aircraft performing services for DOD. All air carriers providing air transportation or operational support services to the DOD shall have FAA or CAA air carrier or commercial operator certificates and shall remain under FAA and/or CAA regulatory and safety oversight during performance of the DOD mission. Aircraft performing services for or on behalf of DOD shall be on the air carrier's operating certificate, and remain on that certificate while performing the DOD mission. The installation of any special equipment needed to perform services for DOD shall be FAA or CAA approved or an appropriate FAA or CAA waiver obtained.

(e) Evaluation requirements. The air carrier requirements stated in this part provide the criteria against which would-be DOD and GSA City Pair Program air carrier contractors, as well as air carriers providing services on behalf of DOD, may be subjectively evaluated by DOD. These requirements are neither all-inclusive nor inflexible in nature. They are not replacements for the certification criteria and other regulations established by the CAA. Rather, these requirements complement CAA certification criteria and regulations and describe the enhanced level of service required by DOD. The relative weight accorded these requirements in a given case, as well as the determination of whether an air carrier meets or exceeds them, is a matter within the sole discretion of the DOD Air Carrier Survey and Analysis Office and the CARB, subject to the statutory minimums provided in the reference in § 861.1(a).

(1) Quality and safety requirements—prior experience. U.S. and foreign air carriers applying for DOD approval in order to conduct air transportation services for or on behalf of DOD under a contract or agreement with DOD, the GSA City Pair Program, or by some other arrangement are required to possess 12 months of continuous service equivalent to the service sought by DOD. In applying this requirement, the following guidance will be used by DOD authorities:

(i) “12 months” refers to the 12 calendar months immediately preceding the request for DOD approval.

(ii) “Continuous” service means the carrier must have performed revenue-generating services of the nature for which DOD approval is sought, as an FAA Part 121, 125, 127, or 135 (14 CFR 121, 125, 127, or 135) air carrier (or foreign CAA equivalent if appropriate) on a recurring, substantially uninterrupted basis. The services must have occurred with such frequency and regularity as to clearly demonstrate the carrier's ability to perform and support sustained, safe, reliable, and regular services of the type DOD is seeking. Weekly flight activity is normally considered continuous, while sporadic or seasonal operations (if such operations are the only operations conducted by the carrier) may not suffice to establish a carrier's ability to perform and support services in the sustained, safe, reliable, and regular manner required by DOD. The ability of a carrier to perform services of the type sought by DOD may be called into question if there have been lengthy periods of time during the qualifying period in which the carrier has not operated such services. Consequently, any cessation, or nonperformance of the type of service for which approval is sought may, if it exceeds 30 days in length during the qualifying period and depending on the underlying factual circumstances, necessitate “restarting” the 12-month continuous service period needed to obtain DOD approval.

(iii) “Equivalent to the services sought by DOD” means service offered to qualify for DOD approval must be substantially equivalent to the type of service sought by DOD. The prior experience must be equivalent in difficulty and complexity with regard to the distances flown, weather systems encountered, international and national procedures, the same or similar aircraft, schedule demands, aircrew experience, number of passengers handled, frequency of operations, and management required. There is not a set formula for determining whether a particular type of service qualifies. The performance of cargo services is not considered to be “substantially equivalent” to the performance of passenger services, and may not be used to meet the 12 continuous months requirement for passenger services. However, when a carrier already providing cargo services to DOD applies to carry passengers, the CARB may consider the carrier's cargo performance and experience in assessing whether a carrier is qualified to carry passengers on a specific type or category of aircraft, over certain routes or stage lengths, or under differing air traffic control, weather, or other conditions. The following examples are illustrative and not intended to reflect or predict CARB action in any given case:

Example 1:

Coyote Air has operated commercial passenger commuter operations in the U.S. for a number of years flying a variety of twin-engine turboprop aircraft. They have also been a DOD-approved cargo carrier, providing international cargo services using DC-10 freighter aircraft. Coyote Air purchases a passenger version DC-10, and seeks DOD approval to provide international passenger service for DOD. The CARB may decide that although Coyote Air has provided Start Printed Page 65702passenger services for 12 continuous months, those services are not substantially equivalent to those being sought by DOD. While the carrier may have considerable operational experience with the DC-10, its commuter passenger operations are not substantially equivalent to the service now proposed—international passenger services on large jet aircraft.

Example 2:

Acme Air has been a DOD-approved cargo carrier for several years, operating domestic and international missions with MD-11 freighter aircraft. At the same time, Acme has been performing commercial international passenger services with B-757 aircraft. Acme Air purchases a MD-11 passenger aircraft and applies to perform passenger services for DOD using the MD-11. Assuming Acme has performed B-757 passenger service for 12 continuous months immediately preceding its application, the CARB may consider these passenger services substantially equivalent to those proposed since both involve the operation of large multi-engine aircraft in an international environment. The CARB may also consider Acme's operational history with its MD-11 freighter aircraft in determining whether the carrier is competent to provide MD-11 passenger service in the same environment.

(iv) Once approved by DOD, an air carrier's failure to maintain continuous operations of the type for which approval has been granted may, at the discretion of the CARB, be grounds for nonuse or suspension under this part, rendering the carrier ineligible for DOD business during the nonuse or suspension period. Any cessation or nonperformance of the type of service for which approval has been obtained may, if it exceeds 30 days in length and depending on the circumstances, provide the basis for the CARB to take appropriate action.

(2) Quality and safety requirements—air carrier management. Management has clearly defined safety as the number one company priority, and safety is never sacrificed to satisfy passenger concern, convenience, or cost. Policies, procedures, and goals that enhance the CAA's minimum operations and maintenance standards have been established and implemented. A cooperative response to CAA inspections, critiques, or comments is demonstrated. Proper support infrastructure, including facilities, equipment, parts, and qualified personnel, is provided at the certificate holder's primary facility and en route stations. Personnel with aviation credentials and experience fill key management positions. An internal quality audit program or other method capable of identifying in-house deficiencies and measuring the company's compliance with their stated policies and standards has been implemented. Audit results are analyzed in order to determine the cause, not just the symptom, of any deficiency. The result of sound fiscal policy is evident throughout the company. Foreign code-sharing air carrier partners are audited at least every two years using DOD-approved criteria and any findings resolved. Comprehensive disaster response plans and, where applicable, family support plans, must be in place and exercised on a regular basis.

(3) Quality and safety requirements—operations—(i) Flight safety. Established policies that promote flight safety. These policies are infused among all aircrew and operational personnel who translate the policies into practice. New or revised safety-related data are promptly disseminated to affected personnel who understand that deviation from any established safety policy is unacceptable. An audit system that detects unsafe practices is in place and a feedback structure informs management of safety policy results including possible safety problems. Management ensures that corrective actions resolve every unsafe condition.

(ii) Flight operations. Established flight operations policies and procedures are up-to-date, reflect the current scope of operations, and are clearly defined to aviation department employees. These adhered-to procedures are further supported by a flow of current, management-generated safety and operational communications. Managers are in touch with mission requirements, supervise crew selection, and ensure the risk associated with all flight operations is reduced to the lowest acceptable level. Flight crews are free from undue management pressure and are comfortable with exercising their professional judgment during flight activities, even if such actions do not support the flight schedule. Effective lines of communication permit feedback from line crews to operations managers. Personnel records are maintained and reflect such data as experience, qualifications, and medical status.

(iii) Flight crew hiring. Established procedures ensure that applicants are carefully screened, including a review of the individual's health and suitability to perform flight crew duties. Consideration is given to the applicant's total aviation background, appropriate experience, and the individual's potential to perform safely. Freedom from alcohol abuse and illegal drugs is required. If new-hire cockpit crewmembers do not meet industry standards for experience and qualification, then increased training and management attention to properly qualify these personnel are required.

(iv) Aircrew training. Training, including recurrent training, which develops and refines skills designed to eliminate mishaps and improve safety, is essential to a quality operation. Crew coordination training that facilitates full cockpit crews training and full crew interaction using standardized procedures and including the principles of Crew Resource Management (CRM) is required. Programs involving the use of simulators or other devices that can provide realistic training scenarios are desired. Captain and First Officer training objectives cultivate similar levels of proficiency. Appropriate emergency procedures training (e.g., evacuation procedures) is provided to flight deck and flight attendant personnel as a total crew whenever possible; such training focuses on cockpit and cabin crews functioning as a coordinated team during emergencies. Crew training—be it pilot, engineer, or flight attendant—is appropriate to the level of risk and circumstances anticipated for the trainee. Training programs have the flexibility to incorporate and resolve recurring problem areas associated with day-to-day flight operations. Aeromedical crews must also be trained in handling the specific needs of the categories of patients normally accepted for transportation on the equipment to be used. Trainers are highly skilled in both subject matter and training techniques. Training received is documented, and that documentation is maintained in a current status.

(v) Captain upgrade training. A selection and training process that considers proven experience, decision making, crew resource management, and response to unusual situations, including stress and pressure, is required. Also important is emphasis on captain responsibility and authority.

(vi) Aircrew scheduling. A closely monitored system that evaluates operational risks, experience levels of crewmembers, and ensures the proper pairing of aircrews on all flights is required. New captains are scheduled with highly experienced first officers, and new or low-time first officers are scheduled with experienced captains. Except for aircraft new to the company, captains and first officers assigned to DOD charter passenger missions possess at least 250 hours combined experience in the type aircraft being operated. The scheduling system involves an established flight duty time program for aircrews, including flight attendants, carefully managed so as to ensure proper crew rest and considers quality-Start Printed Page 65703of-life factors. Attention is given to the stress on aircrews during strikes, mergers, or periods of labor-management difficulties.

(vii) In-flight performance. Aircrews, including flight attendants and flight medical personnel, are fit for flight duties and trained to handle normal, abnormal, and emergency situations. They demonstrate crew discipline and a knowledge of aviation rules; use company-developed standardized procedures; adhere to checklists; and emphasize safety, including security considerations, throughout all preflight, in-flight, and postflight operations. Qualified company personnel evaluate aircrews and analyze results; known performance deficiencies are eliminated. Evaluations ensure aircrews demonstrate aircraft proficiency in accordance with company established standards. Flight crews are able to determine an aircraft's maintenance condition prior to flight and use standardized methods to accurately report aircraft deficiencies to the maintenance activity.

(viii) Operational control/support. Effective mission control includes communications with aircrews and the capability to respond to irregularities or difficulties. Clear written procedures for mission preparation and flight following aircraft and aircrews are provided. There is access to weather, flight planning, and aircraft maintenance data. There are personnel available who are knowledgeable in aircraft performance and mission requirements and that can correctly respond to emergency situations. There is close interface between operations and maintenance, ensuring a mutual awareness of aircraft operational and maintenance status. Procedures to notify DOD in case of an accident or serious incident have been established. Flight crews involved in such accidents or incidents report the situation to company personnel who, in turn, have procedures to evaluate the flight crew's capability to continue the mission. Aircraft involved in accidents or incidents are inspected in accordance with Civil Aviation Regulations and a determination made as to whether or not the aircraft is safe for continued operations.

(ix) DOD charter procedures. Detailed procedures addressing military charter requirements are expected. The level of risk associated with DOD charter missions does not exceed the risks inherent in the carrier's non-DOD daily flight operations. Complete route planning and airport analyses are accomplished, and actual passenger and cargo weights are used in computing aircraft weight and balance.

(4) Quality and safety requirements—maintenance. Maintenance supervisors ensure all personnel understand that in spite of scheduling pressure, peer pressure, supervisory pressure, or other factors, the airplane must be airworthy prior to flight. Passenger and employee safety is a paramount management concern. Quality, completeness, and integrity of work are trademarks of the maintenance manager and maintenance department. Nonconformance to established maintenance practices is not tolerated. Management ensures that contracted maintenance, including repair and overhaul facilities, is performed by maintenance organizations acceptable to the CAA.

(i) Maintenance personnel. Air carriers are expected to hire and train the number of employees required to safely maintain the company aircraft and support the scope of the maintenance operations both at home station (the company's primary facility) and at en route locations. These personnel ensure that all maintenance tasks, including required inspections and airworthiness directives, are performed; that maintenance actions are properly documented; and that the discrepancies identified between inspections are corrected. Mechanics are fit for duty, properly certificated, the company verifies certification, and these personnel possess the knowledge and the necessary aircraft-specific experience to accomplish the maintenance tasks. Noncertified and inexperienced personnel received proper supervision. Freedom from alcohol abuse and illegal drugs is required.

(ii) Quality assurance. A system that continuously analyzes the performance and effectiveness of maintenance activities and maintenance inspection programs is required. This system evaluates such functions as reliability reports, audits, component tear-down reports, inspection procedures and results, tool calibration program, real-time aircraft maintenance actions, warranty programs, and other maintenance functions. The extent of this program is directly related to the air carrier's size and scope of operation. The cause of any recurring discrepancy or negative trend is researched and eliminated. Action is taken to prevent recurrence of these discrepancies and preventive actions are monitored to ensure effectiveness. The results of preventive actions are provided to appropriate maintenance technicians.

(iii) Maintenance inspection activity. A process to ensure required aircraft inspections are completed and the results properly documented is required. Also required is a system to evaluate contract vendors, suppliers, and their products. Inspection personnel are identified, trained (initial and recurrent), and provided guidance regarding inspector responsibility and authority. The inspection activity is normally a separate entity within the maintenance department.

(iv) Maintenance training. Training is conducted commensurate with the size and type of maintenance function being performed. Continuing education and progressive experience are provided for all maintenance personnel. Orientation, familiarization, on-the-job, and appropriate recurrent training for all full and part-time personnel are expected. The use of such training aids as mockups, simulators, and computer-based training enhances maintenance training efforts and is desired. Training documentation is required; it is current, complete, well maintained, and correctly identifies any special authorization such as inspection and airworthiness release. Trainers are fully qualified in the subject manner.

(v) Maintenance control. A method to control maintenance activities and track aircraft status is required. Qualified personnel monitor maintenance preplanning, ensure completion of maintenance actions, and track deferred discrepancies. Deferred maintenance actions are identified to supervisory personnel and corrected in accordance with the criteria provided by the manufacturer or regulatory agency. Constant and effective communications between maintenance and flight operations ensure an exchange of critical information.

(vi) Aircraft maintenance program. Aircraft are properly certified and maintained in a manner that ensures they are airworthy and safe. The program includes the use of manufacturer's and CAA information, as well as company policies and procedures. Airworthiness directives are complied with in the prescribed time frame, and service bulletins are evaluated for applicable action. Approved reliability programs are proactive, providing management with visibly on the effectiveness of the maintenance program; attention is given to initial component and older aircraft inspection intervals and to deferred maintenance actions. Special tools and equipment are calibrated.

(vii) Maintenance records. Maintenance actions are well documented and provide a complete record of maintenance accomplished and, for repetitive actions, maintenance required. Such records as aircraft log books and maintenance documentation Start Printed Page 65704are legible, dated, clean, readily identifiable, and maintained in an orderly fashion. Inspection compliance, airworthiness release, and maintenance release records, etc., are completed and signed by approved personnel.

(viii) Aircraft appearance. Aircraft exteriors, including all visible surfaces and components, are clean and well maintained. Interiors are also clean and orderly. Required safety equipment and systems are available and operable.

(ix) Fueling and servicing. Aircraft fuel is free from contamination, and company fuel facilities (farms) are inspected and results documented. Procedures and instructions pertaining to servicing, handling, and storing fuel and oil meet established safety standards. Procedures for monitoring and verifying vendor servicing practices are included in this program.

(x) Maintenance manuals. Company policy manuals and manufacturer's maintenance manuals are current, available, clear, complete, and adhered to by maintenance personnel. These manuals provide maintenance personnel with standardized procedures for maintaining company aircraft. Management policies, lines of authority, and company maintenance procedures are documented in company manuals and kept in a current status.

(xi) Maintenance facilities. Well maintained, clean maintenance facilities, adequate for the level of aircraft repair authorized in the company's CAA certificate are expected. Safety equipment is available in hangars, shops, etc., and is serviceable. Shipping, receiving, and stores areas are likewise clean and orderly. Parts are correctly packaged, tagged, segregated, and shelf life properly monitored.

(5) Quality and safety requirements—security. Company personnel receive training in security responsibilities and practice applicable procedures during ground and in-flight operations. Compliance with provisions of the appropriate standard security program, established by the Transportation Security Administration or foreign equivalent, is required for all DOD missions.

(6) Quality and safety requirements—specific equipment requirements. Air carriers satisfy DOD equipment and other requirements as specified in DOD agreements.

(7) Quality and safety requirements—oversight of commuter or foreign air carriers in code-sharing agreements. Air carriers awarded a route under the Passenger Standing Route Order (PSRO) program, the GSA City Pair Program, or other DOD program, that includes performance of a portion of the route by a commuter or foreign air carrier with which it has a code-sharing arrangement, must have a formal procedure in place to periodically review and assess the code-sharing air carrier's safety, operations, and maintenance programs. The extent of such reviews and assessments must be consistent with, and related to, the code-sharing air carrier's safety history. These procedures must also provide for actual inspections of the foreign code-sharing air carrier if the above reviews and assessments indicate questionable safety practices.

(8) Quality and safety requirements—aeromedical transport requirements. (i) The degree of oversight is as determined by the CARB or higher authority. When an inspection is conducted, DOD medical personnel may also participate to assess the ability to provide the patient care and any specialty care required by DOD. The CARB's review will be limited solely to issues related to flight safety.

(ii) Portable Electronic Devices (PEDs) used in the provision of medical services or treatment on board aircraft are tested for non-interference with aircraft systems and the results documented to show compliance with 14 CFR 91.21 or other applicable CAA regulations. If there are no CAA regulations, actual use/inflight testing of the same or similar model PED prior to use with DOD patients is the minimum requirement.

DOD Commercial Airlift Review Board procedures

(a) This section establishes procedures to be used by the DOD when, in accordance with references in§ 861.1(a) and (b):

(1) An air carrier is subject to review or other action by the DOD Commercial Airlift Review Board, or CARB;

(2) A warning, suspension, temporary nonuse, or reinstatement action is considered or taken against a carrier by the CARB; or

(3) An issue involving an air carrier is referred by the CARB to higher authority for appropriate action.

(b) These procedures apply to air carriers seeking to provide or already providing air transportation services to DOD. It also applies to U.S. or foreign air carriers providing operational support services to DOD which, on a case-by-case basis and at the discretion of the CARB or higher authority, require some level of oversight by DOD.

(c) An air carrier's sole remedy in the case of a suspension decision by the CARB is the appellate process under this part.

(d) Quality and safety issues relating to air carriers used, or proposing to be used, by DOD, per reference (b) must be referred to the CARB for appropriate disposition.

(e) CARB responsibilities. As detailed in the reference in § 861.1(b), the CARB provides a multifunctional review of the efforts of the DOD Air Carrier Survey and Analysis Office and is the first level decision authority in DOD on quality and safety issues relating to air carriers. Responsibilities include, but are not limited to: the review and approval or disapproval of air carriers seeking initial approval to provide air transportation service to DOD; the review and approval or disapproval of air carriers in the program that do not meet DOD quality and safety requirements; the review and approval or disapproval of air carriers in the program seeking to provide a class of service different from that which they are currently approved; taking action to suspend, reinstate, or place into temporary nonuse or extended temporary nonuse, DOD approved carriers; taking action, on an as needed basis, to review, suspend, reinstate, or place into temporary nonuse or extended temporary nonuse, an air carrier providing operational support services to DOD; and, referring with recommendations, issues requiring resolution or other action by higher authority.

(f) CARB administrative procedures.—(1) Membership. The CARB will consist of four voting members appointed by USCINCTRANS from USTRANSCOM and its component commands. These members and their alternates will be general officers or their civilian equivalent, with experience in the operations, maintenance, transportation, or air safety fields. A Chairman and alternate will be designated. Nonvoting CARB members will be appointed as necessary by USCINCTRANS. A non-voting recorder will also be appointed.

(2) Decisions. Decisions of the CARB will be taken by a majority vote of the voting members present, with a minimum of three voting members (or their alternates) required to constitute a quorum. In the event of a tie, the Chair of the CARB will decide the issue.

(3) Meetings of the CARB. The CARB may meet either in person or by some electronic means. It will be convened by either USCINCTRANS or the Chair of the CARB. The meeting date, time, and site of the CARB will be determined at the time of the decision to convene the CARB. Minutes of CARB meetings will be taken by the recorder, summarized, and preserved with all other records relating to the CARB meeting. The recorder will ensure the air carrier and Start Printed Page 65705appropriate DOD and federal agencies are notified of the CARB's decision(s) and reasons therefore. In the event of a fatal accident, the CARB shall convene as soon as possible but not later than 72 hours after notification by the Chair.

(g) CARB operating procedures.—(1) Placing an air carrier into temporary nonuse. (i) In case of a fatal aircraft accident or for other good cause, two or more voting members of the CARB may jointly make an immediate determination whether to place the air carrier involved into a temporary nonuse status pending suspension proceedings. Prior notice to the air carrier is not required.

(ii) The carrier shall be promptly notified of the temporary nonuse determination and the basis therefore.

(iii) Temporary nonuse status terminates automatically if suspension proceedings are not commenced, as set out in paragraph (g)(2) of this section, within 30 days of inception unless the CARB and air carrier mutually agree to extend the temporary nonuse status.

(2) Suspension of an air carrier. (i) On a recommendation of the DOD Air Carrier Survey and Analysis Office or any individual voting member of the CARB, the CARB shall consider whether or not to suspend a DOD approved air carrier.

(ii) If the CARB determines that suspension may be appropriate, it shall notify the air carrier that suspension action is under consideration and of the basis for such consideration. The air carrier will be offered a hearing within 15 days of the date of the notice, or other such period as granted by the CARB, at which the air carrier may be present and may offer evidence. The hearings shall be as informal as practicable, consistent with administrative due process. Formal rules of evidence do not apply.

(iii) The types of evidence which may be considered includes, but is not limited to:

(A) Information and analysis provided by the DOD Air Carrier Survey and Analysis Office.

(B) Information submitted by the air carrier.

(C) Information relating to action that may have been taken by the air carrier to:

(1) Correct the specific deficiencies that led the CARB to consider suspension; and

(2) Preclude recurring similar deficiencies.

(D) Other matters the CARB deems relevant.

(iv) The CARB's decisions on the reception or exclusion of evidence shall be final.

(v) Air carriers shall have the burden of proving their suitability to safely perform DOD air transportation and/or operational support services by clear and convincing evidence.

(vi) After the conclusion of such hearing, or if no hearing is requested and attended by the air carrier within the time specified by the CARB, the CARB shall consider the matter and make a final decision whether or not to suspend the air carrier or to impose such lesser sanctions as appropriate. The air carrier will be notified of the CARB's decision.

(3) Reinstatement. (i) The CARB may consider reinstating a suspended carrier on either CARB motion or carrier motion, unless such carrier has become ineligible in the interim.

(ii) The carrier has the burden of proving by clear and convincing evidence that reinstatement is warranted. The air carrier must satisfy the CARB that the deficiencies, which led to suspension, have been corrected and that action has been implemented to preclude the recurrence of similar deficiencies.

(iii) Air carrier evidence in support of reinstatement will be provided in a timely manner to the CARB for its review. The CARB may independently corroborate the carrier-provided evidence and may, at its option, convene a hearing and request the participation of the air carrier.

(4) Appeal of CARB decisions. (i) An air carrier placed in suspension by the CARB may administratively appeal this action to USCINCTRANS. An appeal, if any, must be filed in writing, with the DOD Air Carrier Survey and Analysis Office, and postmarked within 15 workdays of receipt of notice of the CARB's suspension decision. In the sole discretion of USCINCTRANS, and for good cause shown, the suspension may be stayed pending action on the appeal.

(ii) Air carriers shall not be entitled to a de novo hearing or personal presentation before the appellate authority.

(iii) The decision of the appellate authority is final and is not subject to further administrative review or appeal.

(5) Referral of issues to higher authorities. The approval or disapproval of an air carrier for use by DOD, the placing of approved carriers into temporary nonuse status, and the suspension and reinstatement of approved carriers, are all decisions which must be made by the CARB. Other matters may be referred by the CARB to USCINCTRANS for appropriate action, with or without recommendations by the CARB. The CARB will forward for decision, through USCINCTRANS to the Under Secretary of Defense (Acquisition, Technology and Logistics) (USD(AT&L)), all air carrier use/nonuse recommendations involving foreign air carriers other than those providing charter transportation or operational support service to the Department of Defense.

DOD review of foreign air carriers.

Foreign air carriers providing or seeking to provide services to DOD shall be subject to review and, if appropriate, approval by DOD. Application of the criteria and requirements of this part and the degree of oversight to be exercised by DOD, if any, over a foreign air carrier depends upon the type of services performed and, in some instances, by the quality of oversight exercised by the foreign air carrier's CAA. The scope and frequency of the review of any given foreign air carrier under this part will be at the discretion of the CARB or higher authority.

(a) Foreign air carriers seeking to provide or providing air transportation services under a contract or Military Air Transportation Agreement with DOD, or pursuant to another arrangement entered into by, or on behalf of, DOD. Foreign air carriers seeking to provide or providing air transportation services under a contract or Military Air Transportation Agreement with DOD, must meet all requirements of § 861.4, and be approved by the CARB in accordance with § 861.5. This includes foreign air carriers seeking to provide, or providing, airlift services to DOD personnel pursuant to an arrangement entered into by another federal agency, state agency, foreign government, international organization, or other entity or person on behalf of, or for the benefit of, DOD, regardless of whether DOD pays for the airlift services provided. For purposes of establishing the degree of oversight and review to be conducted under the DOD Commercial Air Transportation Quality and Safety Review Program, such foreign air carriers are considered the same as U.S. carriers. In addition, they must have an operating certificate issued by the appropriate CAA using regulations which are the substantial equivalent of those found in the U.S. FARs, and must maintain such certification throughout the term of the contract or agreement. The CAA responsible for exercising oversight of the foreign air carrier must meet ICAO standards as determined by ICAO, or the FAA under the FAA's International Aviation Safety Assessment Program.

(b) Foreign air carriers providing passenger services under the GSA City Pair Program. Foreign air carriers Start Printed Page 65706performing any portion of a route awarded to a U.S. air carrier under the GSA City Pair Program pursuant to a code-sharing agreement with that U.S. air carrier, are generally not subject to DOD survey and approval under §§ 861.4 and 861.5. However, DOD will periodically review the performance of such foreign carriers. This review may consist of recurring performance evaluations, periodic examination of the U.S. code-sharing carrier's operational reviews and assessments of the foreign carrier and, where appropriate and agreed to by the air carriers concerned and DOD, on-site surveys of the foreign air carrier. Such carriers must also meet the 12 months prior experience requirement of § 861.4(e)(1). The CARB or higher authority may prescribe additional review requirements. Should circumstances warrant, use of these air carriers by DOD passengers on official business may be restricted or prohibited as necessary to assure the highest levels of passenger safety.

(c) Other foreign air carriers carrying individually ticketed DOD passengers on official business. Foreign air carriers carrying individually ticketed DOD passengers on official business are not subject to DOD survey and approval under §§ 861.4 and 861.5. However, the DOD Air Carrier Survey and Analysis Division may periodically review the performance of such carriers. Reviews may include voluntary on-site surveys as directed by the CARB or higher authority. In the event questions relating to the safety and continued use of the carrier arise, the matter may be referred to the CARB for appropriate action.

(d) Foreign air carriers from countries in which the CAA is not in compliance with ICAO standards. Unless otherwise authorized, use by DOD personnel on official business of foreign air carriers from countries in which the CAA is not in compliance with ICAO standards is prohibited except for the last leg into and the first leg out of the U.S. on such carriers. This includes foreign air carriers performing any portion of a route awarded to a U.S. air carrier under the GSA City Pair Program pursuant to a code-sharing agreement with that U.S. air carrier.

(e) On-site surveys. The scope of the on-site survey of a foreign air carrier will be at the discretion of the CARB. In the event a foreign air carrier denies a request made under this part to conduct an on-site survey, the CARB will consider all available information and make a use/nonuse recommendation to DOD. If placed in nonuse status by DOD, such air carriers will not be used unless, in accordance with the reference in § 861.1 (b), in the judgment of the appropriate Combatant Commander, no acceptable alternative to using the carrier exists and the travel is mission essential.

(f) Foreign carriers providing operational support services to DOD. Such carriers are subject to DOD oversight, on a case-by-case basis, to the extent directed by the CARB or higher authority.

Disclosure of voluntarily provided safety-related information.

(a) General. In accordance with paragraph (h) of the reference in § 861.1 (a), DOD may withhold from public disclosure safety-related information voluntarily provided to DOD by an air carrier for the purposes of this Part if DOD determines that—

(1) The disclosure of the information would, in the future, inhibit an air carrier from voluntarily providing such information to DOD or another Federal agency for the purposes of this Part or for other air safety purposes; and

(2) The receipt of such information generally enhances the fulfillment of responsibilities under this Part or other air safety responsibilities involving DOD or another Federal agency.

(b) Processing requests for disclosure of voluntarily provided safety-related information. Requests for public disclosure will be administratively processed in accordance with 32 CFR Part 806, Air Force Freedom of Information Act Program.

(c) Disclosure of voluntarily provided safety-related information to other agencies. The Department of Defense may, at its discretion, disclose voluntarily provided safety-related information submitted under this Part by an air carrier, to other agencies with safety responsibilities. The DOD will provide such information to another agency only upon receipt of adequate assurances that it will protect the information from public disclosure, and that it will not release such information unless specifically authorized.

End Part Start Signature

Pamela D. Fitzgerald,

Air Force Federal Register Liaison Officer.

End Signature End Supplemental Information

[FR Doc. 02-27087 Filed 10-25-02; 8:45 am]